Pennsylvania Transport

Oversize/Overweight Permit And Regulations

Pennsylvania Oversize Permits & Escort Information

WE ARE NOT A PERMIT SERVICE NOR DO WE ARRANGE PERMITS FOR CARRIERS.  THIS IS STRICTLY JUST FOR INFORMATIONAL PURPOSES.  WE DO NOT ENSURE THE ACCURACY OF THE BELOW INFORMATION SO BE SURE TO READ YOUR PERMIT SHEETS CAREFULLY!

Pennsylvania Department of Transportation
Phone Number: (717) 412-5300

PERMITS: Pennsylvania oversize permits are valid for seven days. Must have permit prior to entering the state.

OPERATING TIME: Sunrise to sunset Monday through Friday, and Saturday sunrise until noon. Overweight only, not exceeding 107,000 pounds and not exceeding 70′ overall length, operating at prevailing speeds can have continuous travel.

RESTRICTED TRAVEL: Daylight only until noon on Saturdays, and no Sunday travel. Over 10 feet wide and/or 85 feet in length are not allowed any weekend travel. Inside urban areas (see map included with provision sheets), except for holidays, movement is allowed seven days a week from 9:00 a.m. – 4:00 p.m. and 7:00 p.m. to sunset, and also 3:00 a.m. – 7:30 a.m. (but 2 pilots and special lighting required). City permit is required for Philadelphia for all routes except Interstates. Permit travel is usually not allowed from noon the day before the six major holidays and holiday weekends until the following weekday.

PENNSYLVANIA TURNPIKE: A permit must be ordered in advance if width is over 10′, length is over 85′, height is over 13’6, weight is over 125,000 pounds or any axle weight is over 22,400 pounds. Height over 13’6″ is not allowed on the mainline (I-76). Over 11′ wide, over 90′ long or over 15′ rear overhang requires a pilot car. From Memorial Day to Labor Day, O/D loads can travel between dawn to dusk Monday through Thursday, and dawn to noon on Friday. After Labor Day until Memorial Day, they can travel dawn to dusk Monday through Friday and dawn to noon on Saturday. Gross weight of 80,000 – 100,000 pounds is moderately expensive. Over 100,000 pounds is much more expensive. Online (Internet) toll calculator is available at: http://www.paturnpike.com/toll/tollmileage.aspx. PA Turnpike phone number is (717) 939-9551, ext. 2980.

LEGAL DIMENSIONS

Length: 53′ semitrailer (kingpin to center line of rear axle group must not exceed 41′). If combination is legal without load, no permit is required if load is 70′ or less or if overall length is 85′ or less and load is non-divisible (no extra length created by multiple end-to-end pieces). No overhang restrictions. This includes beams, utility poles, pipes, building materials, etc.

Overhang: Up to 6′ rear overhang allowed on a divisible load. No overhang is legal unless it is a non-divisible load as above.

Width:

  • 8’6″ on designated highways
  • 8′ on other roads

Height: 13’6″

Weight: 80,000

  • Steer Axle – 20,000
  • Single – 20,000
  • Tandem – 34,000
  • Tridem – 42,500

ROUTINE PERMIT LIMITS

Length:

  • 120′
  • 160′ on 4-lane highways

Width: 16′

Height: 14’6″

Weight:

  • Single – 27,000
  • Tandem – 52,000
  • Tridem – 63,000
  • Quad – 72,000

Loads exceeding 201,000 gross weight, width over 16 feet, or 160 feet overall length, are considered superloads.

ESCORTS

Length:

  • Over 90′ – 1 escort
  • Over 160′ – police escort

Overhang: Over 15′ – 1 escort

Note: If both length exceeds 90′ and width exceeds 13′, front and rear pilots are required on all two-lane highways.

Width:

  • Over 13′ on all highways – 1 escort
  • Over 16′ – police escort

Height: Over 14’6″ – 1 escort with height pole, and PA requires a route survey to accompany application.

Weight: Over 201,000 – police escort.

Other:

  • If permit reduced speeds over bridges – 1 escort
  • If permit requires load to be only vehicle on a bridge, or to occupy more than one lane of traffic on a bridge – 2 escorts

Philadelphia: Police escort required when over and of the following:

  • 11’5″ wide
  • 14′ high
  • 75′ long
  • 145,000 pounds

MISCELLANEOUS: Dozers with blades that exceed 12′ in width, but no wider than 15′, may be hauled if a traffic protector guide rail device is securely fastened to the dozer. A detached bucket or blade cannot be hauled on an overweight load.

SIGNS, FLAGS & LIGHTS: “Oversize Load” signs are required on front of tractor and rear of load or trailer (whichever extends the farthest) on all oversized loads unless otherwise specified in the permit. Signs must be removed or covered when the vehicle/load is no longer oversize. Flags are required at the widest points of any oversize load. Rear overhang of 4′ or more must be flagged, or have a red light attached to the end of the load during darkness. Headlights and rear lamps of a permitted vehicle must be on during movement when traveling with pilot car(s).

Tailored transport solutions to meet your needs

Understanding your requirements and objectives is important to us. Click below to tell us more about your upcoming shipment.
Request A Quote

Below is a list of the states and where to find their updated permits

Click on the states below for links to the state's guidelines for permitting oversize loads and escorts for over dimensional / heavy haul shipping. These regulations are subject to change for each state. If something doesn't look correct, give us a shout and let us know so we can property update the page.

What can we do for you?
Find out more!

Lets Get Started